Mathematical modeling of the energy reduction system in the lifting transmission units of lifting installations for well repair

Authors

  • S. І. Kryshtopa Ivano-Frankivsk National Technical University of Oil and Gas, 15 Karpatska Street Ivano-Frankivsk Ukraine, 76019
  • L. І. Kryshtopa Ivano-Frankivsk National Technical University of Oil and Gas, 15 Karpatska Street Ivano-Frankivsk Ukraine, 76019
  • І. М. Mykytii Ivano-Frankivsk National Technical University of Oil and Gas, 15 Karpatska Street Ivano-Frankivsk Ukraine, 76019
  • М. М. Hnyp Ivano-Frankivsk National Technical University of Oil and Gas, 15 Karpatska Street Ivano-Frankivsk Ukraine, 76019
  • F. V. Kozak Ivano-Frankivsk National Technical University of Oil and Gas, 15 Karpatska Street Ivano-Frankivsk Ukraine, 76019

DOI:

https://doi.org/10.31471/1993-9868-2021-2(36)-106-119

Keywords:

hoisting installation for repair of wells, oil and gas technological transport, diesel engine, transmission unit, gearbox, heat utilization, exhaust gases, power, specific fuel consumption

Abstract

The work is aimed at solving the problem of reducing energy losses in transmission units of hoisting installations for repairing wells. A method of rapid heating and maintaining the optimal temperature in the transmission units of lifting units by using the heat of the exhaust gases was proposed. The analysis of features of a design of transmissions of lifting installations for repair of wells is carried out. Studies of viscosity-temperature characteristics of modern transmission oils and temperature regime in transmission units have been performed. A mathematical model of energy release in transmission units during the operation of lifting units is proposed. Installed energy consumption for friction in the gears of the transmission units. Friction energy losses in bearings of  transmission mechanisms of lifting units are determined. A method for reducing energy losses in transmission units of hoisting installations for well repair is proposed. Experimental studies of the implementation of the proposed method of reducing energy losses in transmission units have been performed. The dependence of power losses in the gearbox of lifting units depending on the temperature and grade of transmission oil is established. The dependence of power losses in the gearbox of the lifting unit of the UPA 60 / 80A model depending on the temperature and grade of transmission oil is obtained. The results of calculations of fuel consumption in the gearbox of the lifting unit of the UPA 60 / 80A model with different power drives and at different temperatures of transmission oil are given.

References

Denysiuk S.P. Formuvannia polityky pidvyshchennia enerhetychnoi efektyvnosti – suchasni vyklyky ta yevropeiski oriientyry. Enerhetyka: ekonomika, tekhnolohii, ekolohiia. 2013. № 2. P. 7–22. [in Ukrainian]

Enerhetychna stratehiia Ukrainy na period do 2030 roku / Skhvalena rozporiadzhenniam KMU 15 bereznia 2006 r. № 145. URL: http://zakon2.rada.gov.ua/laws/show/145-2006-r. [in Ukrainian]

Enerhozberezhennia. Systemy enerhe-tychnoho menedzhmentu. Vymohy ta nastanova shchodo vykorystannia: DSTUISO50001:2014. K.: Minekonomrozvytku Ukrainy, 2014. 26p. [in Ukrainian]

Ostroverkh O.O., Kozhushko A.P., Shevtsov V.M. Teoretychne doslidzhennia bezstupinchastoi transmisii avtomobilia KrAZ 63221-02 dlia remontu naftohazovykh sverdlovyn. Visnyk Natsionalnoho tekhnichnoho universytetu "KhPI". 2017. №6 (1228). P. 45-51. [in Ukrainian]

Vyrvinskyi P.P., Khomenko V.L. Remont sverdlovyn: Navchalnyi posibnyk. Dnipro-petrovsk: Natsionalnyi hirnychyi universytet, 2003. 219 p. [in Ukrainian]

Buhalenko E.I. Neftepromyislovoe oborudovanie. Spravochnik. Moskva: Nedra, 1990. [in Russian]

Samorodov V. B., Ostroverch A. O., Kozhushko A. P. Development and analysis of stepless two-flowhydro static-mechanical transmission bycriterion of great estefficiency for carsusedtorepairoiland gas wells. «KhPI». The bulletin of the National Technical University "KhPI". 2012. vol. 60. P. 105–111.

Samorodov V. B., Ostroverch A. O., Kozhushko A. P. Analysis of the technological mode of operation of a continuoushydro volume-mechanical transmission using nativehydro-units of a carused torepairoiland gas wells]. The bulletin of the National Technical University "KhPI"]. 2013. Vol. 30. P. 23–31.

Razyapov M.M. Povyishenie raboto-sposobnosti agregatov transmisii avtotraktornoy tehniki v usloviyah nizkih temperatur: avtoref. dis. ... kand. tehn. nauk. Ufa, 2013. 16 p. [in Russian]

Pustozerov Yu.I. Issledovanie ekspluatatsionnyih rezhimov rabotyi transmissii traktora DT-75 v usloviyah nizkih temperatur: avtoref. dis. kand. tehn. nauk. Novosibirsk, 2003. 23p. [in Russian]

Selivanov N.I. Povyishenie effektivnosti rabotyi traktornih agregatov v zimnih usloviyah APK Vostochnoy Sibiri: avtoref. dis. ... d-ra tehn. nauk. Krasnoyarsk, 2006. [in Russian]

Karpov P.M. Povyishenie toplivnoy ekonomichnosti selskohozyaystvennyih traktorov v zimnih usloviyah putem uluchsheniya rezhimov smazki transmissiy (na primere traktora DT-75M): avtoref. dis. ... kand. tehn. nauk. Ulyanovsk, 1988. 25 p. [in Russian]

Kutlin A.A. Issledovanie vliyaniya rezhima dvizheniya avtomobiley na temperaturu ih osnovnih agregatov i rashod topliva v zimnih usloviyah ekspluatatsii: avtoref. dis. ... kand. tehn. nauk. Kiev, 1981. 20 p. [in Russian]

Vasileva L.S. Avtomobilnyie ekspluata-tsionnyie materialyi. M.: Transport, 2006. 279 p. [in Russian]

Published

2021-12-29

How to Cite

Kryshtopa С. І., Kryshtopa Л. І., Mykytii І. М., Hnyp М. М., & Kozak Ф. В. (2021). Mathematical modeling of the energy reduction system in the lifting transmission units of lifting installations for well repair. Oil and Gas Power Engineering, (2(36), 106–119. https://doi.org/10.31471/1993-9868-2021-2(36)-106-119

Issue

Section

NEW SOLUTIONS IN MODERN EQUIPMENT AND TECHNOLOGIES

Most read articles by the same author(s)