Underground pipeline stresses caused by damage near anchor mounting

Authors

  • A. B. Struk ТВЦ Технічної діагностики "Техдіагаз"; 76019, м. Івано-Франківськ, Січинського, 3в, тел. (097) 9313537

DOI:

https://doi.org/10.31471/1993-9868-2019-2(32)-53-60

Keywords:

underground pipeline, anchor, stress, strength, tectonic fault, fracture displacement of the base.

Abstract

The article considers the issues of underground pipeline strength, which are operated in geological or technogenic complication conditions (movements of indigenous soil in the tectonic fault zone, mutual displacements and rotations of rock blocks, etc.). The work aims at studying of a mobility limitation effect of a pipeline anchorage imposed on the stress state in the pipe wall in the site of a local damage foundation. The pipeline static was investigated in a geometrically linear formulation, modeling it with a tubular cross-section, and with a momentless cylindrical shell for straight issues. The interaction of the pipe with a dense base through soil backfill was described by the hypothesis of Winkler's elastic layer. The deformation of the anchored pipe caused by base local continuity disturbances was studied, which was modeled by the given jumps of longitudinal displacement and the block angle of rotation. This approach makes it possible to evaluate the strength of long underground communications not on the external load from the ground, which is usually unknown, but according to the observed parameters of riverside movements. The limiting state of the pipeline under the internal pressure of the transported product and under additional loading from kinematic perturbation was investigated by the energy theory of strength. The authors formulated boundary value problems for differential tensile-compression equations and torsion of a straight bar with discontinuous right-hand sides. On the basis of analytical solutions to the problems, the effect of normal separation crack damage, foundation blocks convergence and their turn around the axis of the pipe on the stress-strain state of the pipeline was studied. Plots of displacement distribution, angles of rotation and equivalent stresses of von Mises are constructed depending on the magnitude and direction of the mutual displacement and reversal of the riverside at different distances from the anchor to the base defect. It has been found that overlapping anchors in the form of anchorage leads to a significant increase in the equivalent stresses in the pipe. It has also been found that for pipes under internal pressure, the approximation of the base blocks is more dangerous than their divergence.

References

Aynbinder A. B. Raschet magistralnyh i promyslovyh truboprovodov na prochnost i ustoychivost. Spravochnoe posobie. M.: Nedra, 1992. 287 p.

Mazur I. I., Ivantsov O. M. Bezopasnost truboprovodnyh sistem. M.: ELIMA, 2004. 1104 p.

Harionovskiy V. V. Nadezhnost i resurs konstruktsiy gazoprovodov. M.: Nedra, 2000. 467 p.

Borodavkin P. P. Podzemnyie magistral-nyie truboprovody. Proektirovanie i stroitelstvo. M.: Nedra, 1982. 384 p.

Kryzhanivs'kyi E. I., Rudko V. P., Shats'kyi I. P. Estimation of admissible loads upon a pipeline in the zone of sliding ground. Materials Science. 2004. Vol. 40, Issue 4. P. 547–551.

Velychkovych A. S., Andrusyak A.V., Pryhorovska T. O., Ropyak L. Y. Analytical model of oil pipeline overground transitions, laid in mountain areas. Oil & Gas Science and Technology – Rev. IFP Energies nouvelles. 2019. Vol. 74, Article Number 65.

Trifonov O. V. Cherniy V. P. Elastoplastic stress-strain analysis of buried steel pipelines subjected to fault displacements with account for service loads. Soil Dynamics and Earthquake Engineering. 2012. Vol. 33, Issue 1. P. 54–62.

Vazouras P., Karamanos S.A., Dakoulas P. Mechanical behavior of buried pipes crossing active strike-slip faults. Soil Dynamics and Earthquake Engineering. 2012. Vol. 61. P. 164–180.

Zhang J., Liang Z., Han C. J. Finite element analysis of wrinkling of buried pressure pipeline under strike-slip fault. Mechanika. 2015. Vol. 21, Issue 3. P. 31–36.

Orynyak I. V., Bogdan A. V. Problem of large displacements of buried pipelines. Part 1. Working out a numerical procedure. Strength of Materials. 2007. Vol. 39, Issue 3. P. 257–274.

Shats’kyi I. P., Struk A. B. Stressed state of pipeline in zones of soil local fracture. Strength of Materials. 2009. Vol. 41, Issue 5. P. 548–553.

Shatskyi I. P., Struk A. B. Deformuvannia pidzemnoho truboprovodu v mistsiakh lokalnoho ruinuvannia osnovy. Dop. NAN Ukrainy. 2009. No 12. P. 69–74.

Shatskyi I., Struk A., Vaskovskyi M. Static and dynamic stresses in pipeline built on damaged foundation. Trans. VŠB – TU Ostrava, Civ. Eng. Ser. 2017. Vol. 17, Issue 2. P. 119–124.

Shatskyi I., Struk A. Otsiniuvannia na-pruzhenoho stanu pidzemnoho truboprovodu za kinematychnymy parametramy roztriskuvannia osnovy. Mekhanika ruinuvannia materialiv i mitsnist konstruktsii / Pid zah. red. V.V.Panasiuka. Lviv: Fiz.-mekh. in-t im. H.V.Karpenka NAN Ukrainy, 2009. P. 981–984.

Published

31.08.2020

How to Cite

Struk, A. B. (2020). Underground pipeline stresses caused by damage near anchor mounting. Oil and Gas Power Engineering, (2(32), 53–60. https://doi.org/10.31471/1993-9868-2019-2(32)-53-60

Issue

Section

MATERIALS, STRUCTURES AND EQUIPMENT OF PETROLEUM COMPLEX FACILITIES